Hi all,
Does anyone have any advice on preventing or even minimizing fret sprout? I've made 4 guitars so far, and all developed fret spout to varying degrees. My most recent build almost immediately!
This last one and the one I am working on are gifts, so I'd hate to give them away, only to have them develop it later.
Currently, I put two coats of stain on my necks and fretboards.
All I can really think of is just holding onto the wood for some time before building, to let them fully dry out.
Any ideas?
Thanks! Dave
Tags:
Maybe a few pics would illustrate the problem? Lots of reasons, cuts not deep enough, cuts too wide, frets not properly seated? Lots of people go without glue on the initial fretting, but gluing them in will keep them put & give more sustain. Plus if you ever have to do a refret, you’ll have to glue them in anyway, so why not from the start? Good luck on the rest of your builds :)
Hi Dave, I would say Brian's spot on with his suggestions, but 'll ad a couple of my observations.
Too narrow a fret slot often leads to having to hit the fret wire too hard, so either putting flat spots on the crown or causing the wire to bend out of the slot.
Too soft a fret board material. The wood fibres are not dense enough to grip the tang
Here's a tip.... Put a radius on the fret wire before tapping the fret in-
tap the ends first and as you tap the high point, the middle of the fret, it pushes the ends outwards slightly and embeds the barbs into the grain fibres better.
I always, with full size necks run a bead of glue along the tang. If the frets are difficult to get along with tap it home a and after every 5 frets place a caul on top of the frets and clamp until glue sets. And then move on.
Taff
If you mean traditional fret sprout ,( like the frets stick out the side as if they are too long now due to wood shrinkage ), Then humidification is the key . Indeed try the dryout first , if the new wood is not the issue (as you suggested) , some folks add humidipaks in a guitar case with it , or store them in a room where you can keep a small humidifier on now and then . not sure what the desirable numbers are .. but you can get humidity readers at wallmart and hardware stores etc I believe . Even cigar shops may have a room reader . check the desired numbers for where you live .
Hi again, I have never heard the term "fret sprout", and thought you were referring to badly seated frets. Your comment, "happens almost immediately" threw me.
Fingerboard/neck shrinkage usually happens over some time and/or if the instrument is transferred to a different climate. To happen immediately is unusual, to me. You say you stain the fingerboard and neck, do you apply any sort of lacquer to limit the taking on and releasing of moisture from the timber.
Acoustic guitars are ideally built in a workshop environment of 50% humidity. This allows for the guitar to acustomise to any new surroundings with its out damage.
Not so important in a CBG. Well the good thing is if it happens almost immediately you got time to correct the problem befor delivery.
Taff
I have had the same issue that developed over time. Like Pic said it was due to low humidity during the heating season here in Ohio. Even after carefully filing the ends flush and finishing the neck with coats of Tung oil. What I do now on all my builds is cut the frets a little short / narrower than the fingerboard and then center the fret on the width so there is a small gap ~1/32 -ish on each end of the fret. Now no sprout ever.
Started by Timothy Hunter in Building Secrets, Tips, Advice, Discussion. Last reply by Southern Ray 19 hours ago. 1 Reply 2 Likes
Started by Timothy Hunter in Other stuff - off topic, fun stuff, whatever. Last reply by Timothy Hunter Mar 21. 11 Replies 2 Likes
Started by Taffy Evans in Building Secrets, Tips, Advice, Discussion. Last reply by Southern Ray Mar 10. 1 Reply 3 Likes
Started by Cigar Box Nation in Feature Articles. Last reply by BrianQ. Mar 9. 4 Replies 3 Likes
Started by Ghostbuttons in Building Secrets, Tips, Advice, Discussion. Last reply by Timothy Hunter Mar 9. 5 Replies 1 Like
Started by Justin Stanchfield in Building Secrets, Tips, Advice, Discussion. Last reply by Taffy Evans Mar 8. 6 Replies 0 Likes
Started by Ken I in Building Secrets, Tips, Advice, Discussion. Last reply by Brian partington Mar 8. 8 Replies 0 Likes
Started by Southern Ray in Cool gear discussion - that's not cigar box related. Last reply by Southern Ray Mar 6. 5 Replies 0 Likes
Started by Taffy Evans in Other stuff - off topic, fun stuff, whatever. Last reply by Taffy Evans Mar 5. 4 Replies 2 Likes
Started by Nomad Jack in Performances, How to Play, Lessons, Concerts. Last reply by Southern Ray Mar 2. 6 Replies 1 Like
Started by Justin Stanchfield in Building Secrets, Tips, Advice, Discussion. Last reply by Carl Floyd Mar 1. 15 Replies 0 Likes
Started by Joe in Performances, How to Play, Lessons, Concerts. Last reply by Carl Floyd Feb 29. 13 Replies 0 Likes
Started by Chance in Building Secrets, Tips, Advice, Discussion. Last reply by Southern Ray Feb 22. 12 Replies 1 Like
Started by Cigar Box Nation in Feature Articles. Last reply by Southern Ray Feb 21. 2 Replies 4 Likes
Started by Brad in Cool gear discussion - that's not cigar box related. Last reply by Southern Ray Feb 19. 6 Replies 3 Likes
Started by Jacob Shook in Building Secrets, Tips, Advice, Discussion. Last reply by Southern Ray Feb 16. 10 Replies 0 Likes
Started by Southern Ray in Performances, How to Play, Lessons, Concerts. Last reply by Southern Ray Feb 16. 2 Replies 0 Likes
Started by Skeesix in Performances, How to Play, Lessons, Concerts. Last reply by Skeesix Feb 6. 2 Replies 1 Like
Started by Timothy Hunter in Other stuff - off topic, fun stuff, whatever. Last reply by Steve M Jan 31. 9 Replies 0 Likes
Started by Mi Rankin in Building Secrets, Tips, Advice, Discussion. Last reply by Justin Stanchfield Jan 27. 5 Replies 0 Likes
Posted by Vlad on March 6, 2024 at 2:32am 5 Comments 2 Likes
Posted by billy jones bluez on February 28, 2024 at 2:09pm 0 Comments 0 Likes
Posted by billy jones bluez on February 17, 2024 at 11:00pm 0 Comments 0 Likes
Posted by Vlad on February 11, 2024 at 1:06am 1 Comment 1 Like
Posted by billy jones bluez on February 8, 2024 at 4:05pm 0 Comments 0 Likes
May 11, 2024 from 11am to 8pm – Speakeasy Grill
0 Comments 0 Likes© 2024 Created by Ben "C. B. Gitty" Baker. Powered by
Cigar Box Nation is presented by C. B. Gitty Crafter Supply, your one-stop-shop for Cigar Box Guitar parts and accessories!